|
IDENTITY: ANAEROBIC
GASKET and FLANGE SEALANT 1518
I. MANUFACTURER: SUR-LOK
CORPORATION
WALWORTH, WISCONSIN, USA 53147
EMERGENCY TELEPHONE: 1-888-784-7711
DATE PREPARED: OCTOBER 16, 2007
II. HAZARDOUS COMPONENTS: NONE
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON
THE TOXIC SUBSTANCE CONTROL ACT (TSCA) INVENTORY OF CHEMICAL SUBSTANCES
MAINTAINED BY THE U.S. ENVIRONMENTAL PROTECTION AGENCY.
III. PHYSICAL / CHEMICAL CHARACTERISTICS:
Boiling Point: >300° F Specific
Gravity: 1.2
Vapor Pressure (mm Hg) <5 @ 30° F Melting Point: N/A
Vapor Density (Air= 1) N/A Evaporation Rate: N/A
Solubility in Water: Partial Appearance /Odor: Red Gel / Mild Odor
IV. FIRE AND EXPLOSION HAZARD DATA:
Flash Point (Method Used): T.C.C.
210° F Flammable Limits: N/A
Extinguishing Media: CO2, Foam, Dry Chemicals
Special Fire Fighting Procedures: Fire can produce dense smoke containing
hazardous products of combustion (see Section V), which may be a hazard
to health. Self contained breathing apparatus and procedures for fighting
chemical fires should be employed. Contains Organic Peroxide.
V. REACTIVITY DATA:
Stable when the instructions for Safe Handling and Use listed in Section VII
are observed. Keep away from Oxidizing and reducing agents. Hazardous
decomposition or by products may include CO, CO2, and Nitrous Oxides.
VI. HEALTH HAZARD DATA:
Possible routes of entry include skin and
ingestion. Organic Peroxide has been reported to cause tumors in
experimental animals when injected under the skin. The low concentration
(<5%) contained in this product should present no danger when used properly
under normal conditions.
This product is not included on any list for carcinogenicity.
Symptoms of prolonged skin contact include
reddened or dry skin, and possibly dermatitis in sensitive individuals
or those with a history of skin disorders. No symptoms are known for the
ingestion of small amounts of this product.
Emergency first aid procedures for skin contact include removal of any
contaminated
clothing and washing the skin thoroughly with soap and water. For eye contact,
flush with water or normal saline for 15 minutes. If irritation
persists, consult a physician. In the event of ingestion, keep calm, do not
induce vomiting. Consult a physician.
VII. PRECAUTIONS FOR SAFE HANDLING AND USE:
Health hazard rating is 1, slightly hazardous. Fire hazard is 1, Flash point
above 200° F. Reactivity rating is 0, stable.
Provide adequate ventilation in area of usage. When possible this should be
achieved by the use of local exhaust ventilation and good general ventilation.
Avoid unnecessary skin and eye contact and always wash hands after use. Gloves
should be used by persons with known skin sensitivities.
Store in original container below 80° F for prolonged shelf life.
In the event of small spills, material may be wiped up and area cleaned with
soap and water. For larger spills, soak up spill with earth, sand, or
absorbent product. Dispose in accordance with State, Federal, and Local
anti-pollution and waste disposal regulations. Large quantities of this
product should not be allowed to enter drains or water lines or be deposited
where it can affect ground or surface waters.
VIII. CONTROL MEASURES:
Transport: This product is not regulated for shipping purposes.
Other: Respiratory protection is not normally
necessary unless product is used in enclosed area of poor ventilation or
individual has a history of chronic respiratory disease. Local exhaust is
recommended. Protective gloves are recommended for individuals with known skin
sensitivities. Always wash hands thoroughly after use.
The information on this data sheet represents
our current data and best opinion as to the proper use in handling of this
product under normal conditions. Any use of the product which is not in
conformance with this data sheet or which involves using the product in
combination with any other product or any other process is the responsibility
of the user.
|
